Yanmar BY series Spezifikationen Seite 110
- Seite / 127
- Inhaltsverzeichnis
- FEHLERBEHEBUNG
- LESEZEICHEN
Bewertet. / 5. Basierend auf Kundenbewertungen
TROUBLESHOOTING
BY Series Operation Manual 103
Diagnostic Trouble Code Table
Code Part or System Mode
Run Or
Condition
Engine
Can Start
Check
Engine
Alarm
No Code Coolant Temp Under 0°C (32°F) 1000 rpm yes no
No Code Coolant Temp Over 108°C (226°F) reduce yes alarm
No Code Charge Air Temp Over 110°C (230°F) reduce yes no
No Code
Boost Pressure
Reading
4BY - over 1.9 bar (27.5 psi)
(relative) or 2.9 bar (42.0 psi)
(absolute)
6BY - over 2.3 bar (33.3 psi)
(relative*) or 3.3 bar (42.9 psi)
(absolute**)
reduce yes alarm
No Code Fuel Temperature Over 90°C (194°F) reduce yes no
No Code Neutral Switch
Only in case of analog throttle
or in case of CAN-fault
(U0001), wrong configuration -
neutral position
no no alarm
P0001 Fuel Metering Unit Not connected reduce yes alarm
P0003 Fuel Metering Unit Short circuit to Ground no no alarm
P0004 Fuel Metering Unit Short circuit to B+ reduce yes alarm
P0087
Fuel Rail Pressure
System Deviation
Fuel rail pressure out of range
reduce or
shut off
depends
on fault
alarm
P0088
Fuel Rail Pressure
System Deviation
Fuel rail pressure out of range
reduce or
shut off
depends
on fault
alarm
P0089
Fuel Rail Pressure
System Deviation
Fuel rail pressure out of range yes yes alarm
P0090
Fuel Pressure Control
Valve
Not connected / valve failure no no alarm
Fuel Rail Pressure
System Deviation
Fuel rail pressure out of range reduce yes alarm
P0091
Fuel Pressure Control
Valve
Short circuit to Ground reduce yes alarm
P0092
Fuel Pressure Control
Valve
Short circuit to B+ no no alarm
P0112
Charge Air Temp Over 125°C (257°F) reduce yes alarm
Charge Air Temp
Sensor
Short circuit to B+ reduce yes alarm
P0113
Charge Air Temp Under -20°C (-4°F) reduce yes alarm
Charge Air Temp
Sensor
No connection / short circuit to
Ground
reduce yes alarm
P0117 Coolant Temp Sensor Short circuit to B+ reduce yes alarm
P0118 Coolant Temp Sensor
No connection / short circuit to
Ground
reduce yes alarm
- BY series 1
- OPERATION MANUAL 2
- BY Series Operation Manual 3
- TABLE OF 4
- CONTENTS 4
- TABLE OF CONTENTS 5
- INTRODUCTION 8
- RECORD OF OWNERSHIP 9
- A DANGER 10
- A WARNING 10
- SAFETY PRECAUTIONS 11
- A CAUTION 11
- 18 BY Series Operation Manual 25
- BY Series Operation Manual 19 26
- 20 BY Series Operation Manual 27
- BY Series Operation Manual 21 28
- 22 BY Series Operation Manual 29
- PRODUCT 30
- OVERVIEW 30
- PRODUCT OVERVIEW 31
- COMPONENT IDENTIFICATION 32
- Top View - 4BY 33
- Left Side - 6BY 33
- Right Side - 6BY 34
- Top View - 6BY 34
- LOCATION OF LABEL AND 35
- NAMEPLATES 35
- FUNCTION OF MAJOR COMPONENTS 36
- FUSES AND RELAYS 38
- ENGINE COVER 39
- BEFORE YOU 40
- BEFORE YOU OPERATE 45
- DIESEL FUEL 46
- ENGINE OIL 49
- 0000005B 50
- Recommended Engine Oil 51
- LongLife 01 Oils 51
- LongLife 04 Oils 54
- Checking Engine Oil 55
- Adding Engine Oil 55
- MARINE GEAR OR STERN 56
- DRIVE OIL 56
- ENGINE COOLANT 56
- Recommended Engine Coolant 58
- POWER STEERING FLUID 59
- DAILY CHECKS 59
- 54 BY Series Operation Manual 61
- OPERATION 62
- ENGINE OPERATION 66
- STARTING THE ENGINE 67
- SHUTTING DOWN THE 68
- CHECKING THE ENGINE 68
- AFTER OPERATION 68
- PERIODIC 70
- MAINTENANCE 70
- PRECAUTIONS 84
- EPA REQUIREMENTS 85
- SCHEDULE 86
- PROCEDURES 90
- Every 50 Hours of Operation 92
- Every 250 Hours of Operation 94
- 008429-00X 95
- 0003659B 100
- PERIODIC MAINTENANCE 101
- TROUBLESHOOTING 104
- TROUBLESHOOTING CHART 105
- Vibration - Drive Disengaged 106
- Vibration - Drive Engaged 106
- Engine Knocks 107
- Low Power Output 107
- Engine Overheat 108
- Engine Runs Cold 108
- Coolant Loss 108
- INFORMATION 109
- LONG-TERM 114
- LONG-TERM STORAGE 115
- Drain Seawater Cooling System 115
- 0003663 116
- SPECIFICATIONS 118
- Tightening Fasteners 121
- EPA WARRANTY 122
- USA ONLY 122
- EPA WARRANTY USA ONLY 123
- Warranty Period: 123
- Warranty Coverage: 123
- Exclusions: 123
- Owner’s Responsibility: 124
- Customer Assistance: 124
Verwandte Produkte und Handbücher für Motor Yanmar BY series
Motor Yanmar 6BY3-260Z Bedienungsanleitung
(68 Seiten)
(68 Seiten)
Motor Yanmar 1GM10 Spezifikationen
(94 Seiten)
(94 Seiten)
Motor Yanmar 4JH5E Bedienungsanleitung
(48 Seiten)
(48 Seiten)
Motor Yanmar ZT350 series Spezifikationen
(58 Seiten)
(58 Seiten)
Motor Yanmar 3YM20 Bedienungsanleitung
(66 Seiten)
(66 Seiten)
Motor Yanmar 1GM10V Spezifikationen
(92 Seiten)
(92 Seiten)
Motor Yanmar BY series Spezifikationen
(104 Seiten)
(104 Seiten)
Motor Yanmar 1GM10 Bedienungsanleitung
(3 Seiten)
(3 Seiten)
Motor Yanmar 6LPA-STP2 Spezifikationen
(699 Seiten)
(699 Seiten)
Motor Yanmar 1GM10V Spezifikationen
(44 Seiten)
(44 Seiten)
Motor Yanmar 6BY3-260Z Bedienungsanleitung
(58 Seiten)
(58 Seiten)
Motor Yanmar 6LYA-STP Spezifikationen
(55 Seiten)
(55 Seiten)
Motor Yanmar 4JH3E Spezifikationen
(65 Seiten)
(65 Seiten)
Motor Yanmar ZT370 Spezifikationen
(60 Seiten)
(60 Seiten)
Motor Yanmar 4JH45 Spezifikationen
(126 Seiten)
(126 Seiten)
Motor Yanmar BY series Installationshandbuch
(28 Seiten)
(28 Seiten)
Motor Yanmar 3GM30F Spezifikationen
(10 Seiten)
(10 Seiten)
Motor Yanmar 6CXM-GTE2 Wartungshandbuch
(132 Seiten)
(132 Seiten)
Motor Yanmar 3JH4E Wartungshandbuch
(214 Seiten)
(214 Seiten)
Motor Yanmar 3JH2 Series Bedienungsanleitung
(308 Seiten)
(308 Seiten)
© 2020, manymanuals.de. Alle Rechte vorbehalten. | 0.075 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Kommentare zu diesen Handbüchern